May 24, 2018
sponsored by Tavant
ISSN 1550-9214         

Telecom Equipment Warranty Report:

As the U.S.-based telephone equipment industry continues to decline and move offshore, the domestic industry's warranty expenses have fallen in step. The exception is Internet and data communications gear, which has come to dominate the entire industry over the past 15 years.

There used to be a thriving U.S.-based telecommunications equipment industry that included hundreds of companies manufacturing products covered by warranties. But fifteen years after the warranty expense reports began, almost three-quarters of them have been acquired or gone out of business.

We began this week's report with a list of 205 U.S.-based companies that have at one time or another reported warranty expenses incurred through the sale of various kinds of telecommunications equipment. We then broke the list into four smaller groups:

  • Internet/Datacomm Equipment (65 companies)
  • Landline/Mobile Phone Equipment (59 companies)
  • Broadcast/Cable TV Equipment (48 companies)
  • Satellite/Microwave Equipment (33 companies)

From each company's annual reports and quarterly financial statements, we collected four essential warranty metrics: the amount of claims paid, the amount of accruals made, the amount of reserves held, and the amount of warranted products sold. With the claims, accruals, and sales figures, we calculated an additional pair of metrics: claims as a percentage of sales, and accruals as a percentage of sales.

Warranty Claims

The most striking aspect of the list is how few companies have survived the tough and changing market of the last 15 years. Many well-known industry veterans, such as Lucent, Motorola, Nortel, and 3Com, have been acquired or sold off in pieces. In fact, of the 205 companies that we started with in 2003, only 50 were still reporting paying claims in 2017. So it's no wonder the warranty expense totals in the charts below are now far below their peaks.

For warranty claims, the peak came all the way back in 2006, when telecom equipment manufacturers paid out just under $2.2 billion in claims. Nearly two-thirds of that total came from sales of telephone network equipment, and only about a quarter of it came from sales of Internet and data communications gear.

Last year, telecom equipment manufacturers paid out $1.12 billion in claims, and well over three-quarters of it came from Internet and datacomm equipment. The landline and mobile phone share had dropped to only 6% of the total, the smallest of the four sub-groups.


Figure 1
Telecom Equipment Warranties
Claims Paid by U.S.-based Companies
(in US$ millions, 2003-2017)

Figure 1


Some of these market slices are so small that we can no longer fit labels into them. The satellite/microwave slide was $90 million in 2017; the TV slice was $91 million last year; and the phone slice was $63 million in 2017. The phone slice actually grew slightly last year, but the others contracted. Overall, the amount of claims paid by all telecom equipment companies fell by $81 million last year.

Two of the biggest proportional declines in claims paid were posted by Harris Corp. and Itron Inc. Each paid out more than 25% less in 2017 than they did in 2016. But the biggest absolute decline belonged to Cisco Systems Inc., which saw its claims cost fall by $76 million, or a little over 10% of its 2016 total.

In terms of increases, there were some spectacular upturns in claims totals. Juniper Networks Inc. saw claims rise by $21 million, or 68%. Broadband equipment provider Calix Inc. saw only a $5.4 million increase in claims, but that represented a 79% increase from 2016. And then Comtech Telecommunications Corp. saw a $4.5 million increase, but that represented an 85% jump in its annual claims cost.

Warranty Accruals

Warranty accruals showed the same pattern as claims, peaking more than a decade ago and then declining ever since. Back in 2006, the industry total for accruals was nearly $2.3 billion, and the telephone equipment sector's share was 65%. Last year, the industry total was $1.08 billion and the telephone sector's share was under 4%.


Figure 2
Telecom Equipment Warranties
Accruals Made by U.S.-based Companies
(in US$ millions, 2003-2017)

Figure 2


Once again, labels don't fit within some of these slices. The satellite/microwave companies accrued $82 million, down by $21 million from 2016 levels. The broadcast/cable equipment companies accrued $77 million, down by $32 million from their 2016 total. The landline/mobile phone equipment companies slipped under $40 million, down from $47 million in 2016. Overall, accruals were down by $134 million last year, a decline of more than 11%.

Once again, Harris was at the top of the list of declines, cutting its accruals by $7.0 million -- more than a third less than in 2016. Arris International plc, which is technically based in the UK but still maintains its operational headquarters near Atlanta, cut its accruals by $16 million, a 30% reduction. Optical multiplexer manufacturer Infinera Corp. cut its accruals by $6.9 million, a 27% reduction. And Juniper Networks reduced its accruals by $6.3 million, a 15% reduction.

There were, however, a handful of accrual increases last year. Netgear Inc. boosted its accruals by $22 million or 20%. Adtran Inc. increased its accruals by just $1.5 million, but that represented an 18% increase for the carrier equipment supplier.

Warranty Expense Rates

In the four charts below, we've taken the claims and accrual totals from the charts above and divided each of them by the corresponding product sales totals, in order to calculate the claims and accrual rates for each of the four sub-groups. And while the data above is in an annual format, the data below is in a quarterly format.

For the Internet/datacomm companies, markets have been expanding and sales have been growing, so the trend lines are the product of many companies' data. But for the other three sub-groups, the number of still-active companies has waned, and sales have declined, so the data is more volatile from one quarter to the next.

In Figure 3, the trend line is solidly declining from 2003 to 2008, and then seems to hit bottom until 2011. From 2012 to 2017, it seems to be rising, except for some sudden drops at the end of 2014 and 2015. In 2017, warranty expense rates for the Internet/datacomm equipment makers were back to 2005 levels.


Figure 3
Internet/Datacomm Equipment Manufacturers
Average Warranty Claims & Accrual Rates
(as a % of product sales, 2003-2017)

Figure 3


Long term, the average expense rates for the Internet/datacomm equipment manufacturers has been around 1.7% for both claims and accruals. The standard deviation for the group is 0.2% for the claims rate and slightly higher for the accrual rate.

For the landline/mobile phone network equipment companies, the long term average warranty expense rate has been closer to 1.3%, with a much more volatile 0.5% standard deviation. Over the past 15 years, this group's expense rates have been as high as 2.1% and as low as 0.3%, though they've remained below one percept for all of the past five years.


Figure 4
Landline/Mobile Phone Equipment Manufacturers
Average Warranty Claims & Accrual Rates
(as a % of product sales, 2003-2017)

Figure 4


Also, notice that in both 2016 and 2017 the phone equipment group's average accrual rate has declined significantly, to under 0.5%, while their claims rate has remained about the same, at around 0.8% to 0.9%. Part of the reason is the way companies such as Valmont Industries Inc. and Ciena Corp. maintain their warranty accounts. At the end of 2017, Valmont's claims rate was 1.0% while its accrual rate was 0.4%. Ciena's claims rate was 0.8% while its accrual rate was 0.4%.

Broadcast Equipment

In Figure 5, the broadcast and cable television equipment makers have seen their warranty expense rates climb for the past two years. In fact, they're just about right back to where they were in 2003. Long term, the average claims and accrual rates in this sector have been close to 0.6%, with a standard deviation of 0.2% for both. But as can be seen in the chart below, their recent expense rates have been a bit above that long term average.


Figure 5
Broadcast/Cable TV Equipment Manufacturers
Average Warranty Claims & Accrual Rates
(as a % of product sales, 2003-2017)

Figure 5


Large companies in this sector such as Arris have kept their expense rates more or less the same in recent years. However, smaller companies such as Viavi Solutions Inc. and Avid Technology Inc. are helping to drive up the overall average. For instance, Viavi saw its claims rate rise from 0.5% at the end of 2016 to 1.5% at the end of 2017. Avid saw its claims rate jump from 0.9% to 1.2% during the same period.

Satellite/Microwave Equipment

With the satellite and microwave equipment manufacturers, there were a few bad years from 2008 to 2010, but the years before and after saw expense rates remain more or less the same, in a narrow range of 1.0% to 1.5%. The long term average claims rate has been 1.4% while the average accrual rate has been 1.5%. For both expense rates, the standard deviation has been 0.4%. But take away the 2008-2010 data and it was only half as large.


Figure 6
Satellite/Microwave Equipment Manufacturers
Average Warranty Claims & Accrual Rates
(as a % of product sales, 2003-2017)

Figure 6


One big part of the reason for the high expense rates during those years was the elevated warranty costs of Garmin Ltd., makers of satellite-based navigation equipment. In early 2009 its claims rate rose as high as 9.7%, and later on that year its accrual rate was 6.4%. Now, both expense rates are back down below two percent.

Warranty Reserves

Our final metric is the year-ending balance in the warranty reserve funds of these telecom equipment companies. As can be seen in Figure 7, it has undergone a steady decline from 2003 to 2017, falling from just over $2 billion to just under $1 billion. As with the other metrics, the decline has been most prominent in the landline/mobile phone sector, where the departures of Lucent, Avaya, Nortel, and others have dramatically reduced the presence of U.S.-based companies in this market.

In 2003, landline/mobile phone equipment companies accounted for about 63% of the industry's total warranty reserves. By 2017, their share was down to 11%, and the Internet/datacomm equipment makers accounted for 62% of the total. All told, reserves contracted by about $97 million last year, a 9.4% decline.


Figure 7
Telecom Equipment Warranties
Reserves Held by U.S.-based Companies
(in US$ millions, 2003-2017)

Figure 7


All four sub-groups saw reserve balance declines last year. Cisco cut its balance by $19 million, a 5% decline. Juniper cut its balance by $14 million, a 34% decline. Valmont reduced its warranty reserves by $6.4 million. For doing so, both companies made it onto a top 10 chart in the March 15 newsletter. Elsewhere, Arris was down by $12 million, and Ciena was down by $10 million.

And then there were a few companies that increased their warranty reserve balances. Extreme Networks Inc. raised its reserve balance from $10.2 million to $13.0 million, a 27% increase. Both Adtran and Lumentum Holdings Inc. boosted their balances by $1.2 million, a 14% increase for each.

Both Comtech and Harris reduced their warranty reserves by $2.0 million last year. But for Comtech, it was a proportionally larger reduction, since its year-ending 2016 balance was $15 million, to Harris' $29 million. These and other reductions helped reduce the satellite/microwave category's total balance to $895 million, which is below the threshold that allows us to give it a label. Interestingly, that's almost exactly the same balance the group reported back in 2003.

Tavant

 

This Week’s Warranty Week Headlines

Apple adds $50 credit to iPhone battery replacement program.
Forbes, May 24, 2018
JollyApp helps consumers manage warranties and maintenance contracts.
Entrackr (India), May 24, 2018
Growing number of iPhone X users complain of cracked camera lenses.
9 to 5 Mac, May 23, 2018
Iowa car dealer accused of pocketing vehicle service contract premiums.
Newton (IA) Daily News, May 23, 2018
Best Buy expands Geek Squad services to include Total Tech Support.
Minneapolis Star Tribune, May 22, 2018
 

More Warranty Headlines below



Mize Warranty Connect

 

Warranty Headlines (cont’d)

American Home Shield rejects HVAC claim over lawn mower damage.
KMOV-TV St. Louis, May 22, 2018
RoadVantage hires Don Oliver as its senior vice president of operations.
SubPrime Auto Finance News, May 21, 2018
Newport KY partners with Service Line Warranties of America.
Northern Kentucky Tribune, May 21, 2018
Asus modifies U.S. warranty terms on third-party repairs.
Press Release, May 19, 2018
Author writes entire article with defective MacBook Pro keyboard.
Business Insider, May 19, 2018
 

More Warranty Headlines below



ServiceBench for Service Administrators

 

Warranty Headlines (cont’d)

Review says Jeep Cherokee's warranty coverage is average for its class.
Car and Driver, May 18, 2018
Mazda Motors UK renews extended warranty partnership with Allianz.
Business Leader (UK), May 17, 2018
Smart luggage maker Raden unexpectedly shuts down: Goodbye warranties.
Slash Gear, May 17, 2018
Registria secures a new round of funding from Housatonic Partners.
Press Release, May 17, 2018
Peugeot offers promotional 7-year warranty until the end of June.
Car Advice (AU), May 17, 2018
 

More Warranty Headlines below



PCMI - Your technology partner

 

Warranty Headlines (cont’d)

Skoda Financial Services offers extra year of warranty to used car buyers.
Automotive World, May 17, 2018
Attorney Paul Wojcicki to speak at June 14 product recall webinar.
Press Release, May 17, 2018
Alpha Warranty Services CEO Steve Rosenvall wins Bronze Stevie Award.
Press Release, May 16, 2018
New York sues pet store for alleged Pet Lemon Law violations.
Press Release, May 16, 2018
TMW Systems to use Decisiv's Service Relationship Management platform.
Press Release, May 15, 2018
 

More Warranty Headlines below



After Warranty Analytics

 

Warranty Headlines (cont’d)

Santander renews deal to sell GAP products from The Warranty Group.
Motor Trader (UK), May 15, 2018
Textron upgrades warranty claims website.
Aviation International News, May 15, 2018
Review rates 2018 Jeep Compass warranty as average.
Car and Driver, May 14, 2018
Nigerian state demands 5-year warranties from contractors.
The Nation (NG), May 14, 2018
Ford Australia lengthens warranties from 3 to 5 years.
Car Advice (AU), May 13, 2018
 

More Warranty Headlines below



Sign up for a free subscription to Warranty Week:
     subscribe     change of address     unsubscribe


 

Warranty Headlines (cont’d)

Kulicke & Soffa reveals warranty accrual investigation.
Press Release, May 10, 2018
Founder of Allied Home Warranty runs for Texas governor.
Texas Tribune, May 10, 2018
Gamers win as Nintendo caves to FTC demands on warranty repair policy.
Hot Hardware, May 10, 2018
Sony updates warranty policies following FTC warning.
Ubergizmo, May 10, 2018
APCO Holdings names David Vickers as its new chief financial officer.
Press Release, May 9, 2018
 

More Warranty Headlines below



Entigo, Founding Sponsor

 

Warranty Headlines (cont’d)

Nintendo, Sony say you can repair game consoles without voiding warranty.
CNET News, May 9, 2018
Renault Australia cuts Megane RS and Clio RS warranties from 5 to 3 years.
Motoring (AU), May 9, 2018
Dominion Energy Utah & HomeServe investigated over solicitations.
Utah Public Radio, May 9, 2018
BossTek lengthens its warranty to 5 years or 5,000 hours.
Aggregates Manager, May 9, 2018
USS Ford aircraft carrier has manufacturing defects but no warranty.
Bloomberg News, May 8, 2018
California proposes longer truck aftertreatment system warranties.
Trucking Info, May 8, 2018
Belkin International offers extended warranty for secure KVM and KM switches.
Press Release, May 8, 2018
CNA Center to officially open in Chicago as new CNA headquarters on June 1.
Press Release, May 7, 2018
Manitowoc Cranes introduces extended warranty program.
American Cranes & Transport, May 7, 2018
Fitbit warranty costs decline, but so does revenue.
Fox Business, May 6, 2018
Boaters say ethanol blends cause tremendous damage to small engines.
Ellsworth American (Maine), May 5, 2018
Lenovo's PremiumCare service contracts offer on-site repairs.
Lowyat.net (Malaysia), May 4, 2018
Corsair India lengthens warranties from 3 to 5 years.
technuter.com (India), May 4, 2018
Retailers worry about Gibson warranties following its bankruptcy filing.
Channel News (AU), May 4, 2018
Ryder to do warranty work on 800 Anheuser-Busch electric trucks.
Freight Waves, May 3, 2018
ServiceMaster appoints Rex Tibbens as president & CEO of American Home Shield.
Press Release, May 3, 2018
Assurant reports rising net income & net earned premiums.
Press Release, May 3, 2018
Review says BMW 4-Series warranties are shorter than Buick or Kia.
Car and Driver, May 3, 2018
Final judgment still pending in New Braunfels lawsuit against FieldTurf.
San Antonio (TX) Express-News, May 3, 2018
Truck Master Warranty appoints Joe Gelfo as president.
Transport Topics, May 3, 2018
PCMI uses Rackspace hosting service to keep its PCRS application running.
Press Release, May 2, 2018
BBC show Watchdog questions Apple warranty repair practices.
9 to 5 Mac, May 2, 2018
Home warranty buyers should do more online research, BBB says.
WDAF-TV Kansas City MO, May 2, 2018
Reporter writes about his extended warranty blues over broken stove.
Fayetteville (GA) Citizen, May 1, 2018
Joseph Simons sworn in as chairman of the Federal Trade Commission.
Press Release, May 1, 2018
Guilford High School turf field splitting apart at the seams after 2 yrs.
WTNH-TV New Haven CT, May 1, 2018
Protective Asset Protection explains survey results.
SubPrime Auto Finance News, April 30, 2018
Dominion Energy partners with HomeServe USA in Utah.
KPCW-FM Park City UT, April 30, 2018
StrucSure Home Warranty hires Aubrey Peluso as claims counsel.
Press Release, April 30, 2018
Rideshare Guardian offers VSCs to Uber & Lyft drivers.
SubPrime Auto Finance, April 27, 2018
Review says 2018 Hyundai Elantra's warranty is one of the best.
Car and Driver, April 27, 2018
Allianz Partners UK sells warranties online to used car owners
Motor Trader (UK), April 27, 2018
Indiana fines Capitol Motors for selling worthless warranties.
Press Release, April 27, 2018
Ally Financial reports brisk vehicle service contract volume growth.
Crain's Detroit Business, April 26, 2018
A.M. Best affirms A rating of Old United Casualty Company.
Press Release, April 26, 2018
 

More Warranty Headlines